2004 Chevrolet Impala
Mileage
158,264
Service Date
2/15/2024
Services Performed
- Lubricate and check chassis. Change oil and oil filter. Check all fluid levels and tire pressures. Perform basic safety inspection. Front pads at 6mm. Rear pads less than 2mm. **Front wheel hubs have play. Rack and pinion boot torn. -Engine mounts & trans mount should be replaced.
- Interface with computer to retrieve data & trouble codes- -P0332 Knock Sensor Bank 2 Circuit Low Bank 2. Test & inspect system- found knock sensor & connections damaged. -P0481 Fan 2 Control Circuit Stuck. Test & inspect fan relay- relay defective, replace w/ used relay. OK at this time -P0455 Evap System Large Leak Detected. Found purge solenoid hose assembly damaged. Replace. -P1811 Maximum Adapt on Long Shift. -Customer declined repairs at this time.
- Pressure test & inspect for leaks- found multiple leaks. Radiator corroded & leaking. recommend replace radiator, both hoses, thermostat & flush system. – Rack and pinion leaking & power Steering pump seeping & noisy. Front outer tie rods, front wheel hubs/bearings have play. -Oil pan, oil pressure switch & rear main seal leaking. Customer advised & opted to only do coolant repairs at this time.
- Found windshield wiper motor is missing wires- will need in-depth diagnosis. Wiper blades old.
- RADIATOR – Remove & Replace
- THERMOSTAT – Remove & Replace – 3.8L Eng
- Pressure test cooling system. Flush engine, radiator, and heater core in both directions. Check thermostat and electric cooling fan operation. Inspect hoses and clamps.
Maris W. gave our service a 5 star review on 2/19/2024
